Remove transfer case shifter and move it aside, if equipped. To buy a particular transmision, place your order online or call our sales staff at 1-866-612-9788 with the stock number. Good luck and hope this helps. Note location of braces for installation. BodyTypeFilter selectedBodyTypeGroupIdList, bodyTypeGroupIdToNameMap, null ; bodyTypeFilter. Please make sure to read the product description below and in particular match the engine size and number of speed with your vehicle's specifications. Lower transmission far enough to provide clearance for other components.
This is a direct replacement to your original factory unit. Cable from throttle linkage, if equipped. Tighten all bolts to specification, and fill transmission with fluid. Mark front drive shaft and remove from transfer case, if equipped. Remove cooler lines, and cap all openings.
Remove support bracket at catalytic converter. We will not process your order before verifying with you the engine information! FuelTypeFilter selectedFuelTypeList, null ; fuelTypeFilter. Relieve fuel pressure, and remove fuel lines. Remove electrical connectors from transmission. I have a reman trans for the truck, but I have never pulled a trans with a transfer case before. WheelSystemFilter selectedWheelSystemList, null ; wheelSystemFilter. InstalledOptionsFilter selectedInstalledOptionIdList, installedOptionIdToLabelMap, possiblyDroppedOptionsMap ; installedOptionsFilter.
Slide transmission straight back, off locating pins, and install Converter Holding Strap J-21366. If the rebuilt trans has 120k on it, the story has just changed and its not a nice ending. Since 1919, Standard Motor Products has engineered a full line of engine management products, including ignition parts, sensors and on-board computers. Browse these listings for your restoration parts and accessories such as this AutoTrust Platinum Speed Sensor! Torque converter must be against flexplate and rotate freely by hand. DealRatingFilter selectedRatingList, null ; ratingFilter. AutoTrust Platinum supplies a growing selection of low-priced transmission and shifter components!.
Remove speedometer harness and vacuum modulator line, if equipped. Since 1918, Dorman Products has supplied the automotive aftermarket with high-quality replacement parts, hardware and fasteners. TransmissionFilter selectedTransmissionList, transmissionTemplate ; } listingsSearchManager. Mark rear drive shaft for installation reference and remove from vehicle. I have a 93 k1500 4x4,i have 230k on it, rebuilt trans at 120k, What happens is that i start out 1-2 gear fine, then no 3 rd gear, just revs, but if i manually shift 2nd gear take it up to about 40 mph and shift to drive it goes into drive and runs fine. Walker Products supplies the automotive aftermarket with premium engine sensors and fuel system components. EngineFilter selectedEngineList, null ; engineFilter.
ColorFilter selectedColorList, 'exteriorColorFilter', 'exteriorColorName', 'Color', 'colors', null ; colorFilter. Ensure all reference marks align. I also pulled the fuse and manually shifted also, no problem. SellerTypeFilter selectedSellerTypeList, null ; sellerTypeFilter. It is comparable to original manufacturer's standards to ensure premium quality and consistent operation. I also can start with the shifter in drive, take off punching it with the high rpm's it also shifts into drive.
I have routinely changed fluid and filter, also changed out shifter soloniod, no difference. I was wanting to know if there are any transmission and transfer case removal and installation issues I need to be aware of before I start? Take care not to burn up the transmission by running it hard while your in the limp mode. Mark flexplate and torque converter alignment. Remove dipstick tube and seal. To install, reverse removal procedure. Here are the removal and installation procedures.
TruckCabinFilter selectedCabinList, null ; truckCabinFilter. A possible adjustment might help your shifting problem. Notes: Some vehicles come with several transmission options and could be very confusing. All Replacement brand items are backed by 1-year, unlimited-mileage warranty. DoorsFilter selectedDoorsList, null ; doorsFilter.
NewUsedFilter selectedNewUsedList, null ; newUsedFilter. SinceLastVisitFilter false, 1557093979203 ; listingsSearchManager. Support transmission with transmission jack. Note location of any brackets or clips and move them aside. . . .
. . . . .